Along with the BT-50, the D-Max is the oldest design here. It has a new tailgate, new alloys and a ‘shark-fin’ antenna. Inside there’s a new instrument cluster and a touchscreen on the mid-spec variants, but that’s the extent of its most recent (MY15.5) updates.
As before, the tub has four decent tie-down hooks and, with the 800kg loaded and secured, the rear ride height dropped around 60mm – as good as the least affected of all the utes here.
Our total payload of 970kg (including driver, etc) is 40kg to 80kg shy of the max figures of the various D-Max dual-cab 4x4 pick-ups, so very close to max payload.
With the 800kg pallet in the tub and heading up, the D-Max felt a little nose-up at the front, but it didn’t bottom out on any of the bumps. And while the steering felt a little light, the chassis felt generally composed, stable and confident.
Not so good is the D-Max’s 3.0-litre engine that felt the weight of the tub more than any of the others in the test. While the maximum power of 130kW is competitive with the less powerful engines here, its 380Nm of torque max is between 53Nm and 90Nm less. This translates to less power off idle and at low rpm, something you don’t want when hauling a big load.
The D-Max still got the job done, but it had to work at it. It is, after all, a much older engine design than any of the others here, and even predates this generation D-Max. The engine refinement is also nothing special here.
The five-speed auto also does the engine few favours. Not only does it have fewer ratios than all but the Triton’s auto, but there’s nothing flash also about the way it shifts up or down the hill. Like the engine, it’s an older design.
But there is a flipside to all this in as much as the D-Max’s engine is a robust and reliable Isuzu design that’s done more than a few laps. Likewise, the gearbox is well proven.
With the deadline for Euro 5 emission compliance looming, Isuzu will have to do something engine-wise for the D-Max for MY17, even if it’s just an addition of a diesel particulate filter. Perhaps the changes will run deeper than that, and there will be more power and torque.
The unassuming Isuzu and its lack of pretence make it a sentimental favourite with many. The hard-working Isuzu shares the underpinnings of the Holden Colorado, yet it has been the preferred choice as a workhorse for those in the know. A virtually bulletproof 3.0-litre engine and five-speed auto transmission combo has gone a long way to building this reputation over a relatively short period of time.
The Isuzu took our load reasonably well. The D-Max’s bum sagged a little under the weight, but its stoicism gives you the impression it’ll have a crack at anything.
In this current climate, however, the D-Max has been seriously challenged in terms of performance and refinement by the new utes.
In true Isuzu fashion, the D-Max had a serious crack at the title. The venerable 130kW/380Nm powerplant aimed to please, but was left wanting. It also lacks electronic trailer sway control.
The generational lag between the Isuzu and the rest of the flock is very apparent at max weight. On uphill drags the D-Max roared, clambered and snorted, yet didn’t deliver the kind of performance set by its rivals. The tacho hovered at 3000rpm in second slot and it stayed there as the D-Max hauled its way to the top of the hill.
The rear end also had a tough time with a bit of bump steer out back. Steering feel remained reasonably composed, and the Isuzu was easily controlled on the up and down. Again, the fivespeed self-shifter may be a tough unit, but it’s not the most intuitive On the upside, the engine did help hold back our load on the downhill runs once there was some manual intervention.
You do, however, get the impression that the Isuzu would take this sort of beating day in and day out without a hiccup.
The D-Max is one of the oldest designs here, so is it up to competing with the new boys?